Solar Water Heater Maintenance Checklist

Two major factors affecting the performance of properly sited and installed solar.

Solar water heater maintenance checklist.

Open a hot water. Solar water heating system maintenance and repair periodic inspection list. Turn off cold water supply and open drain valve. Satisfactory not satisfactory 2 quantity of hot water supply.

Close drain valve and open cold water supply valve. Install pump onto the water heater discharge using pipe fitting. If that is too. With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out.

Regularly scheduled maintenance should include. If it is then you are set to refill the tank. Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for. Before you begin inspect all of the valves.

If water is milky drain entire tank. The pump should be installed so that the pump is pumping away from the hot water heater towards the solar panel. Open t p relief valve to relieve pressure. Preventing scaling and corrosion.

Let the water run until it stops flowing. Solar hot water heaters are no different except that because they have more components there is more that can go wrong. Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector. Drain the water from the hot water pipe.

Don t miss the temperature and pressure valves. Also read your owner s manual. Turn off the heat. Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater.

1 temperature of hot water. Satisfactory not satisfactory 3 constant temperature e g. Use a solution of dish soap and warm. Allow a few gallons worth of water to drain.

Whether the tank is gas or electric turn off its heating source the night before. Here are some suggested inspections of solar system components. When calling for assistance please have the following. Be sure to check the water draining out and make sure it is clear.

Drain 2 3 gallons of water.